What did you do to your van today?

Gresley · Post by **Gresley** » Mon Nov 04, 2013 9:43 pm

Removed the badly done silver wrap from my cluster frame and sprayed it instead. Too much work.

Pipsical · Post by **Pipsical** » Mon Nov 04, 2013 9:48 pm

Good effort ^^^^

Replaced the dog bone/ subframe bush.
Started drilling spot welds for rear seats.

Dubsteps · Post by **Dubsteps** » Tue Nov 05, 2013 1:32 pm

Just finished spraying my touran wing mirrors

Gresley · Post by **Gresley** » Wed Nov 06, 2013 4:55 pm

Made aluminium trims for gear stick and cup holder. I used 4mm plate and it cost about £5.

Templated.

Cut with jigsaw.

I then used a belt sander to take most of the corners off.

Hand sanded the rest.

Sanded to 1200 grit.

Finished it with t-cut to give a satin look.

Just got the cup holder to do. Was too dark to take pics of it in position.

nutsnvolks · Post by **nutsnvolks** » Wed Nov 06, 2013 9:42 pm

Well I limo blacked the side windows on my maxi life and fitted wind deflectors, hopefully my chrome side bars will turn up tomorrow so I can fit them and get some pics

Fish · Post by **Fish** » Wed Nov 06, 2013 10:04 pm

I booked my van in to have a new steering rack fitted

Patr1ck · Post by **Patr1ck** » Thu Nov 07, 2013 2:49 pm

smartezippo wrote: Did the other side today I was better the second time round! very pleased

Did you remove the door rubbers to install the carpet or did you just carpet to the edge ?

Patr1ck · Post by **Patr1ck** » Thu Nov 07, 2013 2:50 pm

Removed the ply lining ready to carpet line

smartezippo · Post by **smartezippo** » Thu Nov 07, 2013 5:21 pm

I pulled the rubber of. It gives a cleaner finish when the rubber is back on plus the metal gives an nice edge to run your knife to trim the carpet.

Bigharty · Post by **Bigharty** » Thu Nov 07, 2013 5:40 pm

Full cleaning session Including snow foam,wash with two bucket method,pat dryer with monster towels then two coats of zymol then coat of poor boys wheel sealant then dressed tyres. Now watch it rain tommorow

wiggi28 · Post by **wiggi28** » Fri Nov 08, 2013 5:32 pm

taxed it

120 quid for 6 months

Longman · Post by **Longman** » Fri Nov 08, 2013 5:39 pm

Washed her and desanded the inside from kiting trips over the last few weeks

Give her a quick polish with some poorboys blackhole !!

Longman · Post by **Longman** » Fri Nov 08, 2013 5:40 pm

Gresley wrote:Made aluminium trims for gear stick and cup holder. I used 4mm plate and it cost about £5.

Any pics of these fiited yet??

DubVrs · Post by **DubVrs** » Fri Nov 08, 2013 7:00 pm

Checked my air filter and it was so dirty so treated the caddy to a new piper cross panel filter. Also fitted a black leather handbrake cover with white stitching.

2012 Audi TT air vents have arrived so may have a play over the weekend.

Gresley · Post by **Gresley** » Fri Nov 08, 2013 9:06 pm

Longman wrote:
Any pics of these fiited yet??

Not just yet Longman. I had to re-do both trims as I took too much off the inside, which left the corners of the plastic visible if that makes sense. Just finished the gear stick trim so will take a pic tomorrow.

CADDY2K.com

What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?

Re: What did you do to your van today?